Trusted ac repair for Elkhorn properties. Same-day service available, transparent pricing, and a workmanship guarantee.
When your air conditioner in Elkhorn, Wisconsin blows warm air, short cycles, or fails to start, KIC Refrigeration technicians identify the exact cause through systematic testing of the refrigerant circuit, compressor windings, capacitors, and control board. We restore reliable cooling performance with precision repairs that address the root problem, not just the symptoms.
Properties throughout Elkhorn (pop. 10,050) face unique demands when it comes to ac repair. Wisconsin heating loads, cooling calculations, and the insulation levels and duct configurations found in Elkhorn homes all influence the approach we take. KIC Refrigeration tailors every ac repair project to the conditions your property actually faces — no generic solutions.
Choosing the right contractor for ac repair in Elkhorn, WI makes all the difference between efficient comfort and a system that short-cycles. KIC Refrigeration uses Manual J load calculations, installs to manufacturer specifications, and backs every project with a warranty. Call (866) 858-2961 to schedule your free assessment.
How our NATE-certified technicians deliver quality ac repair results from start to finish.
KIC Refrigeration begins every AC repair in Elkhorn, WI with a systematic assessment. We verify 24-volt control voltage at the thermostat, check high and low voltage wiring for damage, inspect the disconnect for burned contacts, confirm the breaker is properly sized, and visually inspect both indoor and outdoor units before powering up the system for testing.
We test capacitors, contactors, relays, and the compressor windings with a multimeter. We connect manifold gauges to measure suction and discharge pressures, calculate superheat and subcooling, and compare all readings to the manufacturer specification for your unit.
Our Elkhorn technician replaces the failed part with the correct replacement for your unit make, model, and tonnage. If the failure involves the sealed refrigerant system, we recover the charge, make the repair, pressure test with nitrogen, evacuate to below 500 microns, and weigh in the correct charge of R-410A or the specified refrigerant.
KIC Refrigeration verifies every AC repair in Elkhorn, WI with a comprehensive performance test. We confirm temperature split, superheat, subcooling, compressor amperage, condenser fan amperage, blower CFM, and thermostat operation. We document all readings and explain the results before we consider the job complete.
Get answers to the ac repair questions our customers ask most often.
AC repair in Elkhorn typically costs $150 to $500 for common component failures including run capacitors ($150 to $250), contactors ($150 to $350), condenser fan motors ($250 to $500), and blower motors ($300 to $600). Compressor replacement is the most expensive repair at $1,500 to $3,500 depending on unit tonnage and whether the system uses R-410A or older R-22 refrigerant. Evaporator coil replacement runs $800 to $2,500 including the refrigerant recovery and recharge. KIC Refrigeration provides a detailed written estimate with itemized parts and labor costs before beginning any AC repair at your Elkhorn property so there are no surprises on the invoice.
An AC that repeatedly trips the circuit breaker is a safety issue that should not be ignored or reset repeatedly. The most common causes are a shorted compressor winding drawing excessive amperage, a failing run capacitor that cannot provide the boost needed for compressor startup, a locked rotor condition from a mechanically seized compressor, a ground fault from damaged wiring or a grounded compressor motor, or an undersized breaker that cannot handle the inrush current. Each reset on a breaker weakens it over time. KIC Refrigeration performs thorough electrical diagnostics at your Elkhorn property — including megohm resistance testing on compressor windings and amperage measurements — to identify the root cause and repair it safely.
Most AC repairs in Elkhorn are completed in 1 to 2 hours during a single service visit. Capacitor and contactor replacements are quick fixes that take 15 to 30 minutes of hands-on time. Fan motor and blower motor replacements take 1 to 2 hours including wiring and testing. Compressor replacement is the most time-intensive repair at 3 to 6 hours because it requires refrigerant recovery with an EPA-certified machine, compressor removal, new compressor installation, nitrogen-purged brazing, pressure testing at 300 PSI, evacuation to below 500 microns, and recharging by weight. KIC Refrigeration arrives at your Elkhorn home with a fully stocked truck to complete most repairs in a single visit.
AC refrigerant recharge in Elkhorn costs $200 to $500 for R-410A systems at roughly $50 to $80 per pound, and $400 to $1,200 for older R-22 systems at $80 to $150 per pound due to the phaseout-driven supply shortage. However, simply adding refrigerant without finding the leak is a temporary and wasteful fix — the charge will leak out again in weeks or months and you will be back in the same situation. KIC Refrigeration always locates the leak first using electronic leak detectors and UV dye, repairs the leaking component, evacuates the system to remove moisture and air, and recharges by weight to the manufacturer specification. This approach fixes the problem permanently.
Hear from property owners who chose us for their heating and cooling needs.
"Called for an emergency AC repair on a Friday evening fully expecting to wait until Monday. They came out that same night. Cannot say enough good things."
"KIC Refrigeration has serviced our commercial HVAC system for two years now. Always professional, always on time. Would not trust anyone else."
"KIC Refrigeration installed our new heat pump system and the difference is incredible. Our energy bills dropped noticeably the very first month."